T. Eljaddi, S. Ragueneau, C. Cordier, A. Lange, M. Rabiller, et al.. Ultrafiltration to secure shellfish industrial activities: Culture of microalgae and oyster fertilization. Aquacultural Engineering, 2021, 95, pp.102204. ⟨10.1016/j.aquaeng.2021.102204⟩. ⟨hal-03514653⟩ Plus de détails...
Shellfish farming, a key sector of French aquaculture activity, allows the production of oyster spat in a controlled environment. Their production in commercial hatcheries requires control over the quality of the seawater used to sustain crossbreeding, breeding, and the production of fodder microalgae. Therefore, improving the filtration conditions of incoming water is crucial in ensuring the sustainability of production. An ultrafiltration pilot plant was therefore installed at Vendee Naissain. This ultrafiltration pilot plant allows filtration at 0.02 mu m; it is used upstream of hatcheries to eliminate pathogens and parasites that can influence the development of cultivated species and downstream to remove oyster gametes in hatchery effluents. The objectives of this work were: (i) to use ultrafiltered seawater for the culture of the microalga Isochrysis lutea (T-Iso) to determine whether better growth than that observed with borehole water, historically used by the producer, can be achieved; and (ii) to determine whether the use of ultrafiltered water results in better fertilization rates of the cupped oyster Crassostrea gigas compared to filtered and UV-treated seawater. Ultrafiltered water has shown definite efficiency for culturing T-Iso with rapid growth and significant reduction in contamination compared to cultivation in well water. The contribution of ultrafiltered water in hatching is more nuanced; ultrafiltered water does not stabilize hatch rates, and its quality is highly dependent on the quality of the seawater used.
T. Eljaddi, S. Ragueneau, C. Cordier, A. Lange, M. Rabiller, et al.. Ultrafiltration to secure shellfish industrial activities: Culture of microalgae and oyster fertilization. Aquacultural Engineering, 2021, 95, pp.102204. ⟨10.1016/j.aquaeng.2021.102204⟩. ⟨hal-03514653⟩
T. Eljaddi, S. Ragueneau, C. Cordier, A. Lange, M. Rabiller, et al.. Ultrafiltration to secure shellfish industrial activities: Culture of microalgae and oyster fertilization. Aquacultural Engineering, 2021, 95, pp.102204. ⟨10.1016/j.aquaeng.2021.102204⟩. ⟨hal-03597226⟩ Plus de détails...
Shellfish farming, a key sector of French aquaculture activity, allows the production of oyster spat in a controlled environment. Their production in commercial hatcheries requires control over the quality of the seawater used to sustain crossbreeding, breeding, and the production of fodder microalgae. Therefore, improving the filtration conditions of incoming water is crucial in ensuring the sustainability of production. An ultrafiltration pilot plant was therefore installed at Vendee Naissain. This ultrafiltration pilot plant allows filtration at 0.02 mu m; it is used upstream of hatcheries to eliminate pathogens and parasites that can influence the development of cultivated species and downstream to remove oyster gametes in hatchery effluents. The objectives of this work were: (i) to use ultrafiltered seawater for the culture of the microalga Isochrysis lutea (T-Iso) to determine whether better growth than that observed with borehole water, historically used by the producer, can be achieved; and (ii) to determine whether the use of ultrafiltered water results in better fertilization rates of the cupped oyster Crassostrea gigas compared to filtered and UV-treated seawater. Ultrafiltered water has shown definite efficiency for culturing T-Iso with rapid growth and significant reduction in contamination compared to cultivation in well water. The contribution of ultrafiltered water in hatching is more nuanced; ultrafiltered water does not stabilize hatch rates, and its quality is highly dependent on the quality of the seawater used.
T. Eljaddi, S. Ragueneau, C. Cordier, A. Lange, M. Rabiller, et al.. Ultrafiltration to secure shellfish industrial activities: Culture of microalgae and oyster fertilization. Aquacultural Engineering, 2021, 95, pp.102204. ⟨10.1016/j.aquaeng.2021.102204⟩. ⟨hal-03597226⟩
J. Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, L. Simonian, et al.. Ultrafiltration as tertiary treatment for municipal wastewater reuse. Separation and Purification Technology, 2021, 272, pp.118921. ⟨10.1016/j.seppur.2021.118921⟩. ⟨hal-03597706⟩ Plus de détails...
Water reuse is an enduring topic that benefits the society and future generations of mankind. Ultrafiltration (UF) is one of the most cost-effective treatment technologies for improving water quality. In this study, a semiindustrial UF pilot plant with periodical classic backwash (CB) and air backwash (AB) was operated automatically to evaluate its feasibility and sustainability for municipal wastewater reuse and find out the optimized filtration condition. This study carried out 15 filtration conditions to investigate the impacts of flux (J in L center dot h-1 center dot m- 2), filtration cycle time (t in min), and air backwash frequency (BW) on membrane hydraulic filtration performance and membrane fouling management. Through comparative analysis of all conditions in water quality, permeability variation, irreversible fouling management, and water recovery rates, the sustainable conditions J80t40BW1/3 (flux of 80 L center dot h- 1 center dot m- 2, filtration cycle time of 40 min, 1 AB followed with 3 CBs), J60t60BW1/4 (flux of 60 L center dot h- 1 center dot m- 2, filtration cycle time of 60 min, 1 AB followed with 4 CBs), and J60t60BW1/ 3 (flux of 60 L center dot h- 1 center dot m- 2, filtration cycle time of 60 min, 1 AB followed with 3 CBs), stood out from the others with higher overall performances. Additionally, air backwash showed excellent reversibility on membrane fouling control, which was around 1.25-2 times that of CB in average. After all, long term operation on condition J60t60BW1/3 in winter and in summer confirmed that the UF system could provide sustainable and adaptable filtration performance regardless of the temperature and feed water quality. The UF permeate quality is good enough to be reused in non-potable applications as it met reuse guidelines of the World Health Organization, reuse standards of France and the most recent EU regulation for agricultural irrigation. This work confirms the great interest of UF as tertiary treatment for water reuse and gives operational indications for future industrialscale production of reclaimed water.
J. Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, L. Simonian, et al.. Ultrafiltration as tertiary treatment for municipal wastewater reuse. Separation and Purification Technology, 2021, 272, pp.118921. ⟨10.1016/j.seppur.2021.118921⟩. ⟨hal-03597706⟩
J. Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, L. Simonian, et al.. Ultrafiltration as tertiary treatment for municipal wastewater reuse. Separation and Purification Technology, 2021, 272, pp.118921. ⟨10.1016/j.seppur.2021.118921⟩. ⟨hal-03514681⟩ Plus de détails...
Water reuse is an enduring topic that benefits the society and future generations of mankind. Ultrafiltration (UF) is one of the most cost-effective treatment technologies for improving water quality. In this study, a semiindustrial UF pilot plant with periodical classic backwash (CB) and air backwash (AB) was operated automatically to evaluate its feasibility and sustainability for municipal wastewater reuse and find out the optimized filtration condition. This study carried out 15 filtration conditions to investigate the impacts of flux (J in L center dot h-1 center dot m- 2), filtration cycle time (t in min), and air backwash frequency (BW) on membrane hydraulic filtration performance and membrane fouling management. Through comparative analysis of all conditions in water quality, permeability variation, irreversible fouling management, and water recovery rates, the sustainable conditions J80t40BW1/3 (flux of 80 L center dot h- 1 center dot m- 2, filtration cycle time of 40 min, 1 AB followed with 3 CBs), J60t60BW1/4 (flux of 60 L center dot h- 1 center dot m- 2, filtration cycle time of 60 min, 1 AB followed with 4 CBs), and J60t60BW1/ 3 (flux of 60 L center dot h- 1 center dot m- 2, filtration cycle time of 60 min, 1 AB followed with 3 CBs), stood out from the others with higher overall performances. Additionally, air backwash showed excellent reversibility on membrane fouling control, which was around 1.25-2 times that of CB in average. After all, long term operation on condition J60t60BW1/3 in winter and in summer confirmed that the UF system could provide sustainable and adaptable filtration performance regardless of the temperature and feed water quality. The UF permeate quality is good enough to be reused in non-potable applications as it met reuse guidelines of the World Health Organization, reuse standards of France and the most recent EU regulation for agricultural irrigation. This work confirms the great interest of UF as tertiary treatment for water reuse and gives operational indications for future industrialscale production of reclaimed water.
J. Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, L. Simonian, et al.. Ultrafiltration as tertiary treatment for municipal wastewater reuse. Separation and Purification Technology, 2021, 272, pp.118921. ⟨10.1016/j.seppur.2021.118921⟩. ⟨hal-03514681⟩
Clémence Cordier, Tarik Eljaddi, Nadjim Ibouroihim, Christophe Stavrakakis, Patrick Sauvade, et al.. Optimization of Air Backwash Frequency during the Ultrafiltration of Seawater. Membranes, 2020, 10 (4), pp.78. ⟨10.3390/membranes10040078⟩. ⟨hal-02891926⟩ Plus de détails...
The main objective of this paper is to study the effect of new air backwash on dead-end ultrafiltration of seawater with a pilot at semi-industrial scale (20 m3/day). To control membrane fouling, two different backwashes were used to clean the membrane: classical backwash (CB) and new air backwash (AB) that consists of injecting air into the membrane module before a classical backwash. To evaluate the efficiency of AB and CB, a resistance in series model was used to calculate each resistance: membrane (Rm), reversible (Rrev) and irreversible (Rirr). The variation of the seawater quality was considered by integrating the turbidity variation versus time. The results indicate clearly that AB was more performant than CB and frequency of AB/CB cycles was important to control membrane fouling. In this study, frequencies of 1/5 and 1/3 appear more efficient than 1/7 and 1/9. In addition, the operation conditions (flux and time of filtration) had an important role in maintaining membrane performance—whatever the variation of the seawater quality.
Clémence Cordier, Tarik Eljaddi, Nadjim Ibouroihim, Christophe Stavrakakis, Patrick Sauvade, et al.. Optimization of Air Backwash Frequency during the Ultrafiltration of Seawater. Membranes, 2020, 10 (4), pp.78. ⟨10.3390/membranes10040078⟩. ⟨hal-02891926⟩
Jiaqi Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, Philippe Moulin. Water Reuse from Municipal Secondary Effluent by Ultrafiltration Becomes a Reality More than Ever. Open Access Journal of Environmental & Soil Science, 2020, 5 (3), pp.655-659. ⟨10.32474/OAJESS.2020.05.000214⟩. ⟨hal-03232125⟩ Plus de détails...
Jiaqi Yang, Mathias Monnot, T. Eljaddi, L. Ercolei, Philippe Moulin. Water Reuse from Municipal Secondary Effluent by Ultrafiltration Becomes a Reality More than Ever. Open Access Journal of Environmental & Soil Science, 2020, 5 (3), pp.655-659. ⟨10.32474/OAJESS.2020.05.000214⟩. ⟨hal-03232125⟩
Journal: Open Access Journal of Environmental & Soil Science
